匀䄀一䤀䘀䰀伀†ᰀ䠀漀眀 吀漀 䤀渀猀琀愀氀氠ᴀ 䜀甀椀搀攀圀栀攀渀 䈀愀搀 吀栀椀渀最猀 䠀愀瀀瀀攀渀 琀漀 䜀漀漀搀 倀氀甀洀戀椀渀最†ጀ 䄀 匀攀愀猀漀渀攀搀 倀爀漀 吀攀氀氀猀 䠀漀眀 吀漀 䌀漀爀爀攀挀琀氀礀 䤀渀猀琀愀氀氀 愀 匀愀渀椀昀氀漀 䴀愀挀攀爀愀琀椀渀最 吀漀椀氀攀琀嬀倀䠀伀吀伀 䌀䄀倀吀䤀伀一㨀 䌀漀渀琀爀愀挀琀漀爀 䴀椀欀攀 䌀漀氀攀琀琀漀Ⰰ 匀愀渀椀昀氀漀 椀渀猀琀愀氀氀愀琀椀漀渀 猀瀀攀挀椀愀氀椀猀琀崀䤀渀猀琀愀氀氀椀渀最 愀 匀愀渀椀昀氀漀 洀愀挀攀爀愀琀椀渀最 瀀氀甀洀戀椀渀最 猀礀猀琀攀洀 椀猀 愀 爀攀氀愀琀椀瘀攀氀礀 猀琀爀愀椀最栀琀昀漀爀眀愀爀搀 愀昀昀愀椀爀†ጀ 漀渀攀 琀栀愀琀 挀愀渀 戀攀 爀攀愀搀椀氀礀 愀挀挀漀洀瀀氀椀猀栀攀搀 眀椀琀栀 愀 栀愀氀昀ⴀ搀愀礠ᤀ猀 眀漀爀欀Ⰰ 洀愀礀戀攀 氀攀猀猀⸀ 匀琀椀氀氀Ⰰ 洀椀猀琀愀欀攀猀 搀漀 栀愀瀀瀀攀渀Ⰰ 愀渀搀 琀栀愀琠ᤀ猀 眀栀攀爀攀 䴀椀欀攀 䌀漀氀攀琀琀漀 挀漀洀攀猀 椀渀⸀吀栀攀 䤀氀氀椀渀漀椀猀 瀀氀甀洀戀椀渀最 挀漀渀琀爀愀挀琀漀爀†ጀ 眀栀漀 椀猀 愀氀猀漀 愀 氀椀挀攀渀猀攀搀 攀氀攀挀琀爀椀挀椀愀渀 眀椀琀栀 栀椀猀 漀眀渀 栀攀愀琀椀渀最 愀渀搀 愀椀爀ⴀ挀漀渀搀椀琀椀漀渀椀渀最 戀甀猀椀渀攀猀猀†ጀ 椀猀 琀栀攀 漀渀ⴀ挀愀氀氀 瀀氀甀洀戀攀爀 昀漀爀 倀爀漀昀攀猀猀椀漀渀愀氀 匀愀氀攀猀 愀渀搀 匀攀爀瘀椀挀攀Ⰰ 匀愀渀椀昀氀漠ᤀ猀 䌀栀椀挀愀最漀ⴀ愀爀攀愀 猀愀氀攀猀 愀最攀渀琀⸀ 䤀渀 琀栀椀猀 挀愀瀀愀挀椀琀礀Ⰰ 栀攀 爀攀猀琀漀爀攀猀 瀀漀漀爀氀礀 椀渀猀琀愀氀氀攀搀 匀愀渀椀昀氀漀 甀渀椀琀猀 琀漀 琀栀攀椀爀 瀀爀漀瀀攀爀 瀀攀爀昀漀爀洀愀渀挀攀 氀攀瘀攀氀猀Ⰰ 甀猀甀愀氀氀礀 戀礀 挀漀爀爀攀挀琀椀渀最 猀椀洀瀀氀攀 戀甀琀 猀攀爀椀漀甀猀 攀爀爀漀爀猀⸀ 匀椀渀挀攀 樀漀椀渀椀渀最 倀匀匀 琀眀漀 礀攀愀爀猀 愀最漀Ⰰ 䌀漀氀攀琀琀漀 栀愀猀 猀攀攀渀 椀琀 愀氀氀㨀 昀爀漀洀 洀攀爀攀 漀瘀攀爀猀椀最栀琀猀 琀漀 愀 戀氀愀琀愀渀琀 搀椀猀爀攀最愀爀搀 昀漀爀 瀀氀甀洀戀椀渀最 戀愀猀椀挀猀⸀†ᰀ吀栀攀 渀甀洀戀攀爀ⴀ漀渀攀 洀椀猀琀愀欀攀 䤀 猀攀攀 椀猀 琀栀愀琀 琀栀攀 椀渀猀琀愀氀氀攀爀 搀椀搀渠ᤀ琀 甀猀攀 븀ⴀ椀渀挀栀 瀀椀瀀攀Ⱐᴀ 䌀漀氀攀琀琀漀 猀愀礀猀Ⰰ 渀漀琀椀渀最 琀栀愀琀 眀椀琀栀 漀渀氀礀 琀栀爀攀攀 攀砀挀攀瀀琀椀漀渀猀Ⰰ 琀栀攀 匀愀渀椀昀氀漀 甀渀椀琀猀 愀爀攀 搀攀猀椀最渀攀搀 昀漀爀 琀栀攀 猀洀愀氀氀攀爀ⴀ搀椀愀洀攀琀攀爀 瀀椀瀀椀渀最⸀䄀渀漀琀栀攀爀 挀漀洀洀漀渀 攀爀爀漀爀 椀猀 椀洀瀀爀漀瀀攀爀 瀀椀瀀攀 琀甀爀渀猀Ⰰ 栀攀 猀愀礀猀⸀†ᰀ䤀渀猀琀愀氀氀攀爀猀 猀栀漀甀氀搀 甀猀攀 琀眀漀 㐀㔀ⴀ搀攀最爀攀攀 攀氀戀漀眀猀 椀渀猀琀攀愀搀 漀昀 愀 猀椀渀最氀攀 㤀　ⴀ搀攀最爀攀攀 攀氀戀漀眀 昀漀爀 爀椀最栀琀ⴀ愀渀最氀攀 琀甀爀渀猀 漀渀 搀椀猀挀栀愀爀最攀 瀀椀瀀椀渀最⸀ 䄀渀搀 愀 夀ⴀ挀漀渀渀攀挀琀椀漀渀 猀栀漀甀氀搀 戀攀 甀猀攀搀 昀漀爀 琀愀瀀瀀椀渀最 椀渀琀漀 琀栀攀 瀀氀甀洀戀椀渀最 漀爀 猀攀眀攀爀 猀琀愀挀欀 洀愀椀渀 搀爀愀椀渀Ⰰ 渀漀琀 愀 琀攀攀Ⱐᴀ 栀攀 愀搀搀猀Ⰰ 渀漀琀椀渀最 愀渀漀琀栀攀爀 昀爀攀焀甀攀渀琀 洀椀猀猀琀攀瀀 琀栀愀琀 挀愀渀 爀攀猀甀氀琀 椀渀 戀愀挀欀甀瀀 漀爀 昀氀漀眀 爀攀猀琀爀椀挀琀椀漀渀⸀ 䄀戀漀瘀攀ⴀ昀氀漀漀爀 瀀氀甀洀戀椀渀最 椀猀 瘀攀爀礀 猀椀洀椀氀愀爀 琀漀 猀琀愀渀搀愀爀搀 瀀氀甀洀戀椀渀最Ⰰ 戀甀琀 琀栀攀 琀攀挀栀渀漀氀漀最礀 椀猀 搀椀昀昀攀爀攀渀琀⸀ 䄀猀 愀 爀攀猀甀氀琀Ⰰ 琀栀攀 椀渀猀琀愀氀氀愀琀椀漀渀 瀀爀漀挀攀搀甀爀攀猀 愀爀攀 搀椀昀昀攀爀攀渀琀 椀渀 洀愀渀礀 愀猀瀀攀挀琀猀⸀ 䘀漀爀 攀砀愀洀瀀氀攀Ⰰ 琀栀攀 攀砀琀攀爀渀愀氀 洀愀挀攀爀愀琀漀爀 瀀甀洀瀀 ⠀漀渀 愀氀氀 戀甀琀 琀栀攀 匀愀渀椀挀漀洀瀀愀挀琀 愀渀搀 匀愀渀椀猀琀愀爀 甀渀椀琀猀⤀ 椀猀 攀渀琀椀爀攀氀礀 搀椀昀昀攀爀攀渀琀 昀爀漀洀 挀漀渀瘀攀渀琀椀漀渀愀氀 瀀氀甀洀戀椀渀最⸀†ᰀ䤀渀猀琀愀氀氀愀琀椀漀渀 椀猀 渀漀琀 猀漀洀攀琀栀椀渀最 琀栀愀琀 挀愀渀 漀爀 猀栀漀甀氀搀 戀攀 昀椀渀攀猀猀攀搀Ⱐᴀ 猀愀礀猀 䌀漀氀攀琀琀漀⸀ 䄀氀琀栀漀甀最栀 琀栀攀 瀀爀漀挀攀搀甀爀攀 椀猀 猀椀洀瀀氀攀Ⰰ 攀瘀攀渀 攀砀瀀攀爀椀攀渀挀攀搀 椀渀猀琀愀氀氀攀爀猀 猀栀漀甀氀搀 爀攀瘀椀攀眀 琀栀攀 椀渀猀琀愀氀氀愀琀椀漀渀 最甀椀搀攀 愀渀搀 昀漀氀氀漀眀 椀琀 琀漀 攀渀猀甀爀攀 愀 最漀漀搀 椀渀猀琀愀氀氀愀琀椀漀渀⸀伀瘀攀爀 琀栀攀 礀攀愀爀猀Ⰰ 䌀漀氀攀琀琀漀 栀愀猀 猀攀攀渀 愀 眀椀搀攀 爀愀渀最攀 漀昀 椀渀猀琀愀氀氀愀琀椀漀渀 瀀爀漀戀氀攀洀猀Ⰰ 眀栀椀挀栀 栀攀 昀椀渀搀猀 猀漀洀攀眀栀愀琀 瀀甀稀稀氀椀渀最 挀漀渀猀椀搀攀爀椀渀最 栀漀眀 猀琀爀愀椀最栀琀昀漀爀眀愀爀搀 匀愀渀椀昀氀漀 瀀氀甀洀戀椀渀最 椀猀⸀†ᰀ吀栀攀 椀渀猀琀愀氀氀愀琀椀漀渀 椀猀 瘀攀爀礀 戀愀猀椀挀 愀渀搀 琀栀攀 椀渀猀琀爀甀挀琀椀漀渀猀 猀椀洀瀀氀攀 琀漀 甀渀搀攀爀猀琀愀渀搀Ⰰ 猀漀 洀愀礀戀攀 猀漀洀攀 瀀攀漀瀀氀攀 搀漀渠ᤀ琀 戀漀琀栀攀爀 琀漀 爀攀愀搀 琀栀攀洀⸠ᴀ匀愀渀椀昀氀漀 甀渀椀琀猀 挀愀渀 戀攀 椀渀猀琀愀氀氀攀搀 椀渀 栀愀氀昀 愀 搀愀礀Ⰰ 䌀漀氀攀琀琀漀 猀愀礀猀Ⰰ 攀瘀攀渀 氀攀猀猀 椀渀 猀漀洀攀 氀漀挀愀琀椀漀渀猀⸀†ᰀ䤀 挀愀渀 椀渀猀琀愀氀氀 愀 匀愀渀椀昀氀漀 甀渀椀琀 椀渀 愀戀漀甀琀 琀栀爀攀攀 栀漀甀爀猀⸀ 䤀琠ᤀ猀 爀攀愀氀氀礀 瘀攀爀礀 猀椀洀瀀氀攀 椀渀 洀漀猀琀 挀愀猀攀猀⸠ᴀ 吀栀攀 攀砀瀀攀爀椀攀渀挀攀搀 䌀漀氀攀琀琀漀 漀昀昀攀爀猀 琀栀攀 昀漀氀氀漀眀椀渀最 猀琀攀瀀ⴀ戀礀ⴀ猀琀攀瀀 最甀椀搀攀Ⰰ 愀氀漀渀最 眀椀琀栀 栀攀氀瀀昀甀氀 爀攀洀椀渀搀攀爀猀 琀漀 愀瘀漀椀搀 琀栀攀 挀漀洀洀漀渀 洀椀猀猀琀攀瀀猀 琀栀愀琀 栀攀 椀猀 洀漀猀琀 昀爀攀焀甀攀渀琀氀礀 挀愀氀氀攀搀 椀渀 琀漀 挀漀爀爀攀挀琀⸀ HOW TO INSTALL GUIDE: SANIFLO MACERATING TOILETSaniplus Residential Installation with Concealed Macerator PumpMost of the necessary components are packaged with the Saniflo unit except for the toilet seat and ¾-inch PVC piping. When you are concealing the macerator pump behind a wall, purchase the optional 16-inch Saniflo Extension Pipe as well as an access panel (cover). In addition, the water closet should be raised 3⁄8 of an inch above the macerator to aid gravity flow. Usually, the thickness of the floor covering under the water closet is sufficient if the macerator is set below the finished-floor level.1 Read the installation instructions that come with the Saniflo unit. Identify all of the supplied components and obtain any needed ¾-inch PVC piping and connector pieces, as well as PVC fasteners, cleaner, primer and glue.2 Select an installation site that is within the maximum distance range: no more than a combined 12 feet below the sewer level or 150 feet away from the soil stack. If you plan to attach additional fixtures to the Saniflo unit, they must be located on the same level of the structure.3 Cut into the soil stack material and install a Y-connector for the discharge pipe from the macerator. 4 When the installation will include a concealed macerator pump, ensure there are approximately 12 inches of space behind the framing for the pump. When installing against an outside wall, leave a few inches behind the macerator pump for insulation.5 Tap into or establish a fresh water supply to the installation area, and position the supply line valve 10 to 12 inches off the floor. Use cold water for toilet installations.6 A nearby 15-amp electrical circuit is needed to operate the macerator pump. Due to the close proximity to water, the circuit should be protected with a Ground Fault Circuit Interrupter (GFCI), the blue box in the photo.7 Make sure no water is running. Unplug any sump pumps. [no photo]8 Now prepare the macerator unit for installation. Install the discharge elbow, which has a non-return valve built into it. Secure the elbow with a clamp. Make sure the elbow is seated properly: Press down and twist. 9 Discharge piping should be ¾-inch for most Saniflo units. Make sure the discharge pipe is 12 inches or more off the floor. It must pitch toward the main soil stack at ¼ inch per foot.
㄀　 刀甀渀 愀渀礀 渀攀挀攀猀猀愀爀礀 倀嘀䌀 瀀椀瀀椀渀最⸀ 䤀昀 礀漀甀 渀攀攀搀 愀 爀椀最栀琀ⴀ愀渀最氀攀 琀甀爀渀Ⰰ 甀猀攀 琀眀漀 㐀㔀뀀 攀氀戀漀眀猀 ⠀愀爀爀漀眀猀⤀ 椀渀猀琀攀愀搀 漀昀 愀 猀椀渀最氀攀 㤀　뀀 攀氀戀漀眀⸀ 䴀愀欀攀 猀甀爀攀 琀漀 椀渀猀甀氀愀琀攀 愀渀礀 piping that is susceptible to freezing. 11 Clean, prime and glue all fittings used. 12 The macerator pump must be vented into the house’s vent system, but it can be installed as a wet system vent. Create a connection to vent sewer gas (see Step 3); 12b: Slip the accordion connector onto the rim of the vent hole, which has been pre-cut and trimmed at the factory. 13 Create a 1½-inch PVC vent line at the accordion connector.14 Finish the 1½-inch vent line by tightening the accordion connection. 15 Insert the breather opening cap (above) and cover with the air vent cover (right). Make sure this is not obstructed after installation. 16 If you are not yet ready to add other fixtures (tub-shower, lavatory sink, etc.), install the removable inlet blanking plug in the waste inlet opening (above). Push and twist to fully seat the plug (below).17 If you are concealing the macerator, attach the Extender Pipe (arrow) to the macerator with the accordian connector.18 Center the unit in an area that is approximately 3 feet wide and with 1 to 1½ inches between the wall and the top-back of the tank. 19 Mark the locations of the holes through the mounting holes in the base. Drill holes in the floor. [no photo] 20 Attach the toilet to the macerator pump (or to the Extender Pipe for concealed pumps) as shown above. Secure the macerator pump unit to the floor. [no photo] 21 Secure the toilet to the floor with screws and plastic anchors.22 Attach the tank to the toilet, using the supplied nuts to secure it. 23 Hand-tighten water supply line connection to the toilet.24 Turn on the water. Measure the water level in the tank. Make sure the water level inside the tank is ½ inch below the overflow tube. [no photo]25 Plug in the macerator pump.26 Remember to install a removable panel on the wall in order to have access to the macerator pump. [no photo]27 If you are connecting multiple fixtures, make sure the hot water for the bath and faucet are 104°F or less. [no photo]Congratulations, your Saniflo unit is properly installed.